Installation

SEAT: FRONT SEAT ASSEMBLY (for Manual Seat): INSTALLATION

1. INSTALL FRONT SEAT ASSEMBLY

(a) Place the front seat assembly in the cabin.

NOTICE:
Be careful not to damage the vehicle body.

(b) Connect each connector and clamp under the seat.

(c) Temporarily install the front seat assembly with the 4 bolts.

(d) Lift up the seat track adjusting handle and move the seat to the rearmost position.

(e) Tighten the 2 bolts on the front side of the seat.





Torque : 37 Nm (377 kgf-cm, 27 ft-lbf)

HINT
Tighten the bolts in the order indicated in the illustration.

(f) Lift up the seat track adjusting handle and move the seat to the foremost position.

(g) Tighten the 2 bolts on the rear side of the seat.





Torque : 37 Nm (377 kgf-cm, 27 ft-lbf)

HINT
Tighten the bolts in the order indicated in the illustration.

2. ZERO POINT CALIBRATION AND SENSITIVITY CHECK (for Front Passenger Seat)

Programming and Relearning

3. INSTALL INNER SEAT TRACK COVER

(a) Engage the guide and claw to install the inner seat track cover.





4. INSTALL OUTER SEAT TRACK COVER

(a) Engage the 2 claws to install the outer seat track cover.





5. INSTALL FRONT SEAT HEADREST ASSEMBLY

6. CONNECT CABLE TO AUXILIARY BATTERY NEGATIVE TERMINAL

NOTICE:
When disconnecting the cable, some systems need to be initialized after the cable is reconnected Repair Instruction - Initialization.

7. INSTALL REAR NO. 3 FLOOR BOARD Installation

8. INSTALL REAR DECK FLOOR BOX Installation

9. INSTALL REAR NO. 2 FLOOR BOARD (for Separate Type) Installation

10. INSPECT FRONT SEAT ASSEMBLY

(a) During sliding operation of the front seat, check that the left and right adjusters move together smoothly and lock simultaneously.

If the seat adjusters do not lock simultaneously, loosen the seat mounting bolts to adjust the adjuster position.

(b) w/ Seat Heater Seat System:

Check the seat heater operation.

(1) Turn the power switch to on (IG).

(2) Push the seat heater switch on.

(3) Wait 5 minutes or more and confirm that the seat surface becomes warm.

11. INSPECT SRS WARNING LIGHT

Diagnosis System