Operation CHARM: Car repair manuals for everyone.
Hosted by mcallihan.com

Motronic Engine Control Module Power Supply Relay J271, Checking



Motronic Engine Control Module Power Supply Relay J271, Checking

Special tools, testers and auxiliary items required
- Multimeter
- wiring diagrams

NOTE: The manufacturers test box Adapter Cable (121-point) VAG1598/31 is available for purchase or rental.

Test requirements
- The fuse for the engine electronics OK.
- The Ground (GND) connections at the engine and transmission OK.
- The battery voltage at least 12.5 V.
- The generator OK.
- The ignition is switched off.

Test procedure
- Perform a preliminary check to verify the customers complaint. Preliminary Check

Start diagnosis

Test sequence
- Switch the ignition on.
- Using the Multimeter, check the following wiring connections for voltage.

Motronic Engine Control Measure to
Module (ECM) J623 electrical
connector T94 terminal or
test box socket

4 Battery Positive (B+)
69 Engine Ground (GND)

Specified value: 12.5. battery voltage.

- Switch the ignition off.

If the specified values are not obtained:
- Using the Multimeter, check the wiring connections for an open circuit.

Specified value: Wire resistance max 1.5 Ohms.
- If necessary, repair the wiring connection.
- Erase the DTC memory. Diagnostic Modes 01 - 09.
- Perform a road test to verify repair.

If the DTC does not return:
Repair complete, Generate readiness code. Monitors, Trips, Drive Cycles and Readiness Codes
- End diagnosis.

If the DTC does return and no malfunction is detected in the wiring and the voltage supply was OK:
- Replace the Motronic Engine Control Module (ECM) J623.
- Assembly is performed in the reverse of the removal.

Final procedures
After repair work, the following work steps must be performed in the mentioned sequence:

1. Check the DTC memory. Diagnostic Modes 01 - 09
2. If necessary, erase the DTC memory. Diagnostic Modes 01 - 09
3. If the DTC memory was erased, generate readiness code. Monitors, Trips, Drive Cycles and Readiness Codes

End of Diagnosis