Operation CHARM: Car repair manuals for everyone.
Hosted by mcallihan.com

Oxygen Sensor Heating Before Catalyst Checking



Oxygen sensor heating (Oxygen sensor before Three Way Catalyst), checking

Special tools, testers, measuring instruments and auxiliary items required

- VAG 1551/1552 Scan Tool with VAG 1551/3B adaptor cable
- VAG 1598/22 Test Box
- Fluke 83 Multimeter
- VW 1594 Adaptor kit
- Wiring diagram

Check conditions

- Fuse 29 OK.






- Battery Voltage 11.5 Volts minimum
- Fuel pump relay OK

Test sequence

- Connect VAG 1551/1552 Scan Tool, [1][2][3]Reading and Clearing Diagnostic Trouble Codes
- Start engine and let idle
- Press 0 and 1 buttons to select "Address word" 01 "Engine electronics"

Display will appear as shown

Rapid data transfer HELP
Select function XX


- Press 0 and 8 buttons to select Function 08: "Read measuring value block"
- Press Q button to enter input

Display will appear as shown

Read measuring value block HELP
Input Display group number XXX


- Press buttons 0, 4 and 1 to select "Display group 41"
- Press Q button to enter input

Display will appear as shown (1 to 4 Display zones)

Read measuring value block 41 ->
1 2 3 4


- Check specifications in Display zones 1 and 2 on chart.







If specifications obtained:

- Press -> button.
- Press 0 and 6 buttons to select Function 06: "End data transfer"
- Press Q button to enter input
- Switch OFF ignition.

Continuation

- Disconnect 4-pin harness connector (brown) from Oxygen sensor G39 (before Three Way Catalyst -1-).







- Switch Multimeter to "Resistance measurement" range.
- Connect Multimeter between terminals 1 + 2 of G39 harness connector using jumper wires from VW 1594 adaptor kit






- Measure resistance
- Specification: 0.0 to 19.9 Ohms

If specification not obtained:
- Replace Oxygen sensor G39 (before Three Way Catalyst).

If specification obtained:
- Switch Multimeter to "Voltage measurement" range.
- Connect Multimeter between terminals 1 + 2 of ECM harness connector using jumper wires from VW 1594 adaptor kit






- Start engine and let idle
- Measure Voltage supply
- When Display group 41, Display zone 2 shows

Display, Htg.bC.ON:
Specification: 11.0 to 14.5 Volts
Display, Htg. bC.ON/Htg. bC.OFF (alternating)
Specification: between 0.0 and 12.0 Volts fluctuating

- Switch OFF ignition.

If NO Voltage present:
- Connect VAG 1598/22 Test Box to Control Module harness connector.






- Check wiring for open circuit between Test Box and 4-pin harness connector using Wiring diagram.






- Terminal 2 + socket 27
- Wire resistance: Max. 1.5 Ohms

If specification obtained
- Check wiring between terminal 1 and fuel pump relay J17 using Wiring diagram.

If wiring OK

- Replace Engine Control Module.
- Display Readiness Code, Monitors, Trips, Drive Cycles and Readiness Codes

NOTE:


If DTC memory has been erased or the Engine Control Module was disconnected from its Voltage supply, the Readiness Code must be created again, Monitors, Trips, Drive Cycles and Readiness Codes