Removal

DOOR LOCK: UNLOCK WARNING SWITCH: REMOVAL

CAUTION:
Some of these service operations affect the SRS airbag system. Read the precautionary notices concerning the SRS airbag system before servicing the steering column Service Precautions.

1. TURN FRONT WHEELS TO FACE STRAIGHT AHEAD

2. DISCONNECT CABLE FROM NEGATIVE BATTERY TERMINAL

CAUTION:
Wait at least 90 seconds after disconnecting the cable from the negative (-) battery terminal to prevent airbag and seat belt pretensioner activation.

3. REMOVE LOWER NO. 3 STEERING WHEEL COVER (w/o Front Spoiler) Removal

4. REMOVE LOWER NO. 3 STEERING WHEEL COVER (w/ Front Spoiler) Removal

5. REMOVE LOWER NO. 2 STEERING WHEEL COVER (w/o Front Spoiler) Removal

6. REMOVE LOWER NO. 2 STEERING WHEEL COVER (w/ Front Spoiler) Removal

7. REMOVE STEERING PAD (w/o Front Spoiler) Removal

8. REMOVE STEERING PAD (w/ Front Spoiler) Removal

9. REMOVE STEERING WHEEL ASSEMBLY (w/o Front Spoiler) Removal

10. REMOVE STEERING WHEEL ASSEMBLY (w/ Front Spoiler) Removal

11. REMOVE LOWER INSTRUMENT PANEL FINISH PANEL SUB-ASSEMBLY Removal

12. REMOVE LOWER STEERING COLUMN COVER Removal

13. REMOVE UPPER STEERING COLUMN COVER Removal

14. REMOVE TURN SIGNAL SWITCH ASSEMBLY WITH SPIRAL CABLE SUB-ASSEMBLY Removal

15. REMOVE UPPER INSTRUMENT PANEL SUB-ASSEMBLY

HINT
Refer to the instructions for Removal of the upper instrument panel Removal.

16. REMOVE COLUMN HOLE COVER SILENCER SHEET Removal

17. SEPARATE NO. 2 STEERING INTERMEDIATE SHAFT ASSEMBLY Removal

18. REMOVE INSTRUMENT PANEL SUB REINFORCEMENT Removal

19. REMOVE NO. 3 AIR DUCT SUB-ASSEMBLY Removal

20. REMOVE TRANSPONDER KEY AMPLIFIER Removal

21. REMOVE STOP LIGHT SWITCH ASSEMBLY Removal

22. REMOVE STEERING POST ASSEMBLY (for 2ZR-FE) Removal

23. REMOVE STEERING POST ASSEMBLY (for 2AZ-FE) Removal

24. REMOVE NO. 2 STEERING INTERMEDIATE SHAFT ASSEMBLY Removal

25. REMOVE STEERING COLUMN UPPER WITH SWITCH BRACKET ASSEMBLY Disassembly

26. REMOVE IGNITION OR STARTER SWITCH ASSEMBLY (for Manual Transaxle) Disassembly

27. REMOVE IGNITION OR STARTER SWITCH ASSEMBLY (for Automatic Transaxle) Disassembly

28. REMOVE KEY INTERLOCK SOLENOID (for Automatic Transaxle) Disassembly

29. REMOVE SOLENOID WIRE (for Automatic Transaxle) Disassembly

30. REMOVE IGNITION SWITCH LOCK CYLINDER ASSEMBLY Disassembly

31. REMOVE UNLOCK WARNING SWITCH ASSEMBLY

(a) Remove the unlock warning switch assembly by pushing up the center part and releasing the 2 claws.





HINT
Slide the unlock warning switch in the direction shown by the arrow in the illustration to remove it.