Keyless Entry System - Inoperative

Bulletin No.: 009/95
Issued: 5/24/95
Revised

Category
T

Applicable Model/s
1995
Millenia

Subject
KEYLESS ENTRY SYSTEM MALFUNCTION

APPLICABLE MODELS/VINs

1995 Millenia vehicles with a VIN of JM1TA22**S1140756 and lower.

DESCRIPTION

The "Keyless Entry" system may not function if used in a garage with a remote garage door opener.

The two operating frequencies interfere with each other. The keyless remote system is redesigned to prevent this problem.

If a customer complains of this problem, replace the keyless unit transmitter and short cord with a modified kit.

NOTE:
If additional remote transmitters are needed program those according to the instructions in the workshop manual.

REPAIR PROCEDURES





1. Remove rear seat. Refer to Fig. 1.

2. Locate keyless unit.





3. Remove the original keyless unit. Refer to Fig 2.





4. Install the new keyless unit and new short cord. Refer to Fig. 3

NOTE:
New short cord must be installed.





5. Tape the keyless unit's harness to the rear main harness. This will prevent noise from interference with other parts.

6. Replace the transmitter with a modified part from the service kit.

7. Install rear seat. Tighten installation bolts to 17- 25 Nm (1.7-2.6 Kg-fm, 13-18 ft-lbs)

8. Initialize the modified transmitter according to the instructions in the workshop manual.





9. Check operation of the transmitter. Refer to Fig. 5

^ Close all doors

^ Push lock button on the transmitter (all doors lock)

^ Push unlock button (the driver's side door unlock).

^ Keep unlock button pressed for one (1) second (all doors unlock).

^ Push the trunk button (the trunk unlocks).

^ Push the panic button two (2) times (the horn, hazard and headlights operate intermittently).

^ Push any button other than the panic button (the horn, hazard and headlights stop operating).

PARTS INFORMATION

Part Number Description Quantity

TA18 67 5D0 Service Kit (keyless unit and transmitter) 1

TAY2 67 SH0 Short Cord 1

NOTE:
Additional transmitters must be ordered and initialized.

WARRANTY INFORMATION

(Applies To Verified Customer Complaints On Vehicles Covered Under Normal Warranty. Refer To The SRT Microfiche For Warranty Term Information)

Warranty Type: A
Symptom Code: 64
Damage Code: 9W
Part Number Main Cause: TA18 67 5D0
Quantity: 1
Operation Number: XX0729RX
Labor Hours: 0.7 Hrs.