Recall - EGR System Tune Up Label Incorrect
05.1-32DATE
4/98
Sedan Range
MODEL
1995 MY
XJR
VIN
720001-754303
Recall R691 - Incorrect Emission Control Label - Install Revised Label - U.S. Vehicles
THIS RECALL ACTION APPLIES TO U.S. VEHICLES ONLY
REFER TO TECHNICAL BULLETIN 05.1-33 FOR CANADIAN VEHICLES.
ISSUE:
On all 1995 Model Year XJR Sedan Models within the above VIN range, the factory-installed Emission Control Data Label ("Tune-up Label") was incorrectly specified. This label is applied to the crossmember above the radiator, within the engine compartment. 1995 MY XJ6 4.0L Sedan models with naturally-aspirated AJ16 engines are NOT affected.
The existing label implies that the engine is equipped with an Exhaust Gas Recirculation system which is not the case.
Jaguar Cars will contact customers by mail. The necessary replacement labels for this purpose, bearing the correct wording, will be supplied to you by Jaguar Cars.
ACTION:
On all 1995 MY XJR vehicles, proceed as follows:
1. Check the driver's door B-pillar area for an R691 authorized modification label used both in Canada and the U.S.A. (Illustration 1). If no label is found, continue with step 2.
2. Identify the Emission Control Data Label ("Tune-up Label"), located on the left side of the cross panel above the radiator (Illustration 2).
3. Clean off the existing label.
4. Apply the replacement label over the old label.
5. Apply an R691 authorized modification label to the Driver side B-pillar. (This label will immediately indicate to any other Dealer that the vehicle concerned has already been rectified).
PARTS INFORMATION:
One Vehicle Emission Control Information Label will be supplied to you direct, on a free-of-charge basis. After determining their immediate needs, dealers should order additional labels by contacting the Jaguar Cars Product Legislation & Compliance Dept. at 201-818-8202 or 8025.
WARRANTY INFORMATION:
NOTE:
Always perform a DCS claim search first to determine whether this recall has been performed on this vehicle. The warranty selection under the vehicle inquiry will give a listing of all claims against the vehicle. If R691 appears in the fault code field, do not perform this recall.