Body - Trunk Trim Panel Hangs Down
04-023September 3, 2004
Applies To:
2003-04 Accord 4-Door - ALL
Right Side Trunk Trim Panel Hangs Down or Does Not Fit Properly
(Supersedes 04-023, dated May 7, 2004)
Updated information is shown by asterisks.
PROBLEM
The right side trunk trim panel does not fit properly.
CORRECTIVE ACTION
Drill a hole in the trim panel, and install a 7 mm push-in clip.
PARTS INFORMATION
Clip: P/N 90667-50D-003ZC, H/C 6245518
WARRANTY CLAIM INFORMATION
In warranty:
The normal warranty applies.
Operation Number: 848002
Flat Rate Time: 0.2 hour
Failed Part: P/N 84601-SDA-A01ZA
H/C 7151137
Defect Code: 07404
Symptom Code: 07304
* Template ID: 04-023A*
Skill Level: Repair Technician
Out of warranty:
Any repair performed after warranty expiration may be eligible for goodwill consideration by the District Parts and Service Manager or your Zone Office. You must request consideration, and get a decision, before starting work.
REPAIR PROCEDURE
1. Open the trunk. Locate the hole in the right rear quarter panel.
2. Position the trunk trim panel next to the hole, and make a mark with a felt-tip pen where the panel needs to be drilled.
3. Push the trim panel against the quarter panel, and drill a 6 or 7 mm hole through the panel.
NOTE:
Use a short drill bit, being careful to drill through the trim panel only.
4. Hold the trim panel in place, and install the clip.
Disclaimer