Operation CHARM: Car repair manuals for everyone.
Hosted by mcallihan.com

Body - Wind Noise From Upper Rear of Front Door Windows

03-085

November 25, 2003

Applies To:
2003 Accord L4 - From VIN 1HGCM5...3A000001 thru 1HGCM5...3A132549
2003 Accord V6 - From VIN 1HGCM6...3A000001 thru 1HGCM6...3A097398

Wind Noise From the Upper Rear Corner of the Front Door(s)

SYMPTOM





Wind noise from the upper rear corner of the front door windows at highway speed.

PROBABLE CAUSE

Misplaced foam in the corner of the glass run channel.

CORRECTIVE ACTION

Install EPT sealer to the back of the run channel.

REQUIRED MATERIALS

EPT Sealer 5T: P/N 06991-SA5-000, H/C 2086650 (One roll will repair 200 vehicles.)





WARRANTY CLAIM INFORMATION

In warranty: The normal warranty applies.

Failed Part: P/N 72235-SDA-A11
H/C 7301971

Defect Code: 07407

Symptom Code: 05604

Skill Level: Repair Technician

Out of warranty:
Any repair performed after warranty expiration may be eligible for goodwill consideration by the District Parts and Service Manager or your Zone Office. You must request consideration, and get a decision, before starting work.

DIAGNOSIS

Test-drive the vehicle at highway speeds to verify the customer's complaint of wind noise.

^ If you hear wind noise from the upper rear corner of the front window, go to REPAIR PROCEDURE.

^ If the noise is coming from another location, this service bulletin does not apply. Continue with normal troubleshooting procedures.

REPAIR PROCEDURE

1. Pull down on the glass run channel to separate it from the door frame at the upper rear corner.





2. Cut a 10 x 100 mm piece of EPT sealer 5T, and use a utility knife to taper the ends to fit into the corner.

3. Apply the piece of EPT sealer 5T into the gap.

4. Reinstall the glass run channel into the window frame. Make sure that it is installed properly with the added thickness.

5. Test-drive the vehicle at highway speeds to make sure the noise is gone.





Disclaimer