Fuel Tank - Removal
REMOVAL
WARNING: The fuel system is under constant high pressure even with engine off. Until the fuel pressure has been properly released from the system, do not attempt to open the fuel system. Do not smoke or use open flames/sparks when servicing the fuel system. Wear protective clothing and eye protection. Make sure the area in which the vehicle is being serviced is in a well ventilated area and free of flames/sparks. Failure to comply may result in serious or fatal injury.
WARNING: No sparks, open flames or smoking. Risk of poisoning from inhaling and swallowing fuel. Pour fuel only into appropriately marked OSHA approved containers. Wear protective clothing. Risk of injury to eyes and skin from contact with fuel.
1. Perform the fuel pressure release procedure Service and Repair.
2. Perform the draining fuel tank procedure Procedures
3. Disconnect the negative battery cable (2).
4. Raise and support the vehicle.
5. Remove the left rear tire.
6. Remove the left rear inner splash shield.
7. Disconnect the fuel filler tube vent line.
8. Remove the hose clamp from the fuel filler tube.
9. Remove fuel filler tube from the rubber hose on the fuel tank.
10. Remove the muffler and tailpipe assembly (2) Removal.
11. Remove the propeller shaft Propeller Shaft - Removal.
12. Remove the left underbody splash shield (1).
13. Remove the right underbody splash shield (1).
14. Disconnect the EVAP line in the right rear wheel well.
15. Disconnect the vapor line.
16. Disconnect the fuel supply line.
17. Using a suitable hydraulic jack with a fuel tank adapter, support the fuel tank.
18. Remove the fuel tank support strap retaining bolts.
19. Remove the fuel tank support straps.
20. Carefully lower the fuel tank and pull the fuel filler tube vent line through bracket.
21. Lower and remove the fuel tank from the vehicle.