Recall - Emission System Update: Overview
90bmw05GROUP 12 Engine - Electrical
Bulletin Number 12 01 89 (1795) Page 1 of 3
Woodcliff, Lake, NJ January 1990 Service Engineering
This Service Information Bulletin supersedes S.I. 12 01 89 (1795) dated May 1989. It incorporates a Work Package in the Warranty Status.
Please remove and discard S.I. 12 01 89 (1795) dated May 1989 from your S.I. binder.
SUBJECT: Voluntary Exhaust Emissions Recall Campaign No. 89E-A01
MODELS: 750iL (Produced from September 1987 to June 1988)
BMW of North America, Inc. will initiate a voluntary emission-related recall campaign to correct vehicles that may be in non-compliance with Federal and California Emissions Standards.
The campaign consists of the installation of fuel pump relays of an improved design and a corresponding wiring harness.
This Service Information Bulletin outlines specifics for implementation of this campaign.
Vehicles
Affected: Model Chassis No. Range
750iL 276 5001 276 7855
Parts
Information: The parts kit required for this 750iL Service Action Update can be ordered under P/N 12 51 9 061 688. Should individual parts be required, they can be ordered under the following part numbers:
Description Part Number Quantity
Female round pin 61 13 1 376 206 1
Male spade connector 61 13 1 376 755 2
which will be supplied automatically with each kit ordered.
Corrective
Procedure: Inspect the underhood area (right inner fender) for the Emissions Recall Label No. 89E-A01 as shown below. If this label is present, do not proceed further.
If not present, proceed as follows:
1) Install the improved fuel pump relays, harness and hardware per the attached instructions.
2) All 16 steps should be performed exactly as stated in the same numerical sequence.
3) Check the system's ability to discontinue fuel delivery and injection to the correct cylinder bank as outlined in the attached instructions.
4) With a ball point pen, print your dealer code (5 digits) on the Recall Completion Label (see illustration). Peel label from its backing and affix it to the right inner fender vertical panel.
Warranty
Status: Dealers will be reimbursed for this recall campaign through Campaign Entry.
Defect code: 00 12 01 01 00
Work package # 1:
Installation of improved fuel pump relays, harness and hardware.
Labor allowance: 30 FRU
Part Number Description Ouantity
12 51 9 061 688 Fuel pump relay kit 1
61 13 1 376 206 Female round pin 1
61 13 1 376 755 Male spade connector 2